Air gap membrane distillation: 2. Model validation and hollow fibre module performance analysis

Share/Save/Bookmark

Guijt, C.M. and Meindersma, G.W. and Reith, T. and Haan, A.B. de (2005) Air gap membrane distillation: 2. Model validation and hollow fibre module performance analysis. Separation and Purification Technology, 43 (3). pp. 245-255. ISSN 1383-5866

[img] PDF
Restricted to UT campus only
: Request a copy
345kB
Abstract:In this paper the experimental results of counter current flow air gap membrane distillation experiments are presented and compared with predictive model calculations. Measurements were carried out with a cylindrical test module containing a single hollow fibre membrane in the centre and a well-defined air gap situated around the fibre. The experimental results show that the previous developed predictive model, with membrane parameters determined from gas permeation experiments, describes correctly the dependence of water vapour flux on temperature level, temperature difference, air gap total pressure, hot water flow and membrane type. At atmospheric air gap pressure, the measured fluxes per saturated water vapour pressure difference between the bulk flows (0.08–0.10 kg/m2h mbar) are comparable with those presented in literature. A reduction of the total air gap pressure to the saturated water vapour pressure of the hot water feed flow temperature of 65 °C, raises the flux by a factor of three. Next to the water vapour flux, the energy efficiency of the process is very important. The measured energy efficiencies (typically 85–90% for a 3 mm air gap and a hot water feed temperature of 65 °C) are slightly below the theoretical values (95–98%), which could be explained by a small heat loss to the surroundings. For air gaps of 1.5 mm or smaller, the energy efficiency is reduced to less than 70%, due to thermal conduction across product water bridges between the membrane fibre and the condenser surface. An optimal air gap is about 3 mm wide and has a total pressure that is equal to or slightly below the saturated water vapour pressure of the hot water entering the hollow fibre membrane.
Item Type:Article
Copyright:© 2005 Elsevier Science
Research Group:
Link to this item:http://purl.utwente.nl/publications/67330
Official URL:http://dx.doi.org/10.1016/j.seppur.2004.09.016
Export this item as:BibTeX
EndNote
HTML Citation
Reference Manager

 

Repository Staff Only: item control page

Metis ID: 227259